序号NO.

检查项目及要求

Checking items

检查结果

results

主辅机及其附属系统工作状况是否良好 M/E & A/E

1

主副机的起动系统，如压缩空气、空压机等状况是否正常

The starting systems of the main engine and generator, such as compressed air, air compressors, etc., are in good condition.

Y

N

N/A

2

主副机的燃油系统，如高压油管、高压油泵、燃油滤器、喷嘴等状况是否正常

The fuel system of the main engine and generator, such as high-pressure  pipes , high-pressure fuel pumps, fuel filters, nozzles, etc., are in good condition.

Y

N

N/A

3

主副机的冷却系统，如海底阀、海底滤器、冷却管路等是否良好

The cooling system of the main engine and generator, such as sea inlets, cooling pipelines, etc., are in good condition

Y

N

N/A

4

主副机的本体部件，如排气阀、水套、调速器、活塞环、密封环等是否正常

The body parts of the main engine and generator, such as exhaust valves, water jackets, governors, piston rings, seal rings, etc. are in good condition.

Y

N

N/A

5

集控室主副机的报警系统，如高压燃油泄漏、滑油故障、冷却水高温等是否正常

The alarm system of the main engine and generator in the engine control room for high-pressure fuel leakage, lubricating oil failure, and high temperature of cooling water is working properly.

Y

N

N/A

6

主副机的冷却、燃油、滑油等各管系是否存在明显滴漏

There is obvious leakage in the cooling, fuel, lubricating oil pipes or other piping systems of the main engine and generators.

Y

N

N/A

7

主副机近期的整体运行状况是否存在异常，如异常报警，异常降速、排温过高、冒黑烟等

There are abnormal alarms, abnormal speed reduction, abnormal high temperature or black smoke happened to the main engine and generator.

Y

N

N/A

8

责任船员是否按照体系文件有效落实主副机的保养维护

The crew has maintained the main engine and generators in the light of the SMS document.

Y

N

N/A

主电源和应急电源是否正常 MAIN AND EMERGENCY POWER

1

主发电机是否能够达到额定转速并稳定

The main generator can reach the rated speed and keep stable.

Y

N

N/A

2

多台主发电机是否能够正常并车稳定运行

Multiple main generators can run in parallel and keep stable.

Y

N

N/A

3

应急发电机是否能够正常起动并合闸供电

The emergency generator can power the emergency switch board properly.

Y

N

N/A

4

应急发电机是否能够利用第2能源或人工起动

The emergency generator can be started by a second means of starting set or manually.

Y

N

N/A

5

应急发电机能否在主电失去后于45秒内自动启动

The emergency generator can be automatically started within 45 seconds after the loss of main power.

Y

N

N/A

操舵装置工作状态是否良好 STEERING GEAR

1

舵机管系各接头、阀门及油缸填料处是否渗、漏油

There is obvious leakage at the joints, valves or oil cylinder packing in the steering gear piping system.

Y

N

N/A

2

液压舵机再充液系统是否正常

The refilling system of the hydraulic steering gear is in good condition.

Y

N

N/A

3

液压舵机储存柜备用液压油是否足够

There is enough spare hydraulic oil in the hydraulic steering gear storage cabinet.

Y

N

N/A

4

驾驶台舵机失电报警是否正常

In the event of a power failure to any one of the steering gear power units, an audible and visual alarm can be given on the navigation bridge.

Y

N

N/A

5

驾驶台舵机缺相声光报警是否正常

If any power supply line of the three-phase motor is disconnected, the main engine control room and engine room can send out audible and visual alarms.

Y

N

N/A

6

转舵机构是否发出明显噪音和震动

There is obvious noise and vibration of the rudder steering gear.

Y

N

N/A

7

舵角限位器是否有效

The rudder angle limiter is working properly.

Y

N

N/A

8

不存在不能转舵、只能单侧转舵、转舵时好时坏、滞舵等不正常现象

The steering gear is working properly.

Y

N

N/A

9

责任船员是否按每三个月进行应急操舵演练

The crew conducts emergency steering drills every three months.

Y

N

N/A

10

进入高密度水域，是否为驾驶员配备了合格舵工，并转换为人工操舵

In the areas of high traffic density, establish manual control of the ship’s steering ,and qualified helms person available on bridge.

Y

N

N/A